How to Remove Scratches from Headlights?

Headlights are scratched as plastic lenses age. Due to its yellowish color and scratches, the brightness of the headlights gets affected. In addition, it questions the driver whether they should drive at midnight when clear headlights are a must. Risk of getting pulled over increases at this time.

A good while ago, the automobile industry transitioned from glass to plastic headlight covers (widely called polycarbonate lenses). This plastic cover gets easily damaged, lowering the quality of the light.

Headlights can lose their entire transparency for a variety of causes. The sun’s rays might make them appear dull. If your headlight covers are made of plastic, road debris might damage them.

The debris scattered throughout the vehicle, potentially damaging the headlights and making eyesight less efficient. It also has an impact on the vehicle’s look.

It is possible to remove scratches from your headlight covers using sandpaper, baking soda, and various other methods! Here we’ll show you how to remove scratches from headlights.

How to Remove Deep Scratches From Headlights

Removing deep scratches may look difficult but if you follow the steps this might turn into an easy approach to clean headlights.

Buffing and sandpaper

Here you’ll need a few sandpapers and buffing materials. To make the scratches smooth but not flat, start by wet-sanding them with 600-grit sandpaper. Then, to bring out the shine of your headlight, apply a rubbing or polishing substance.

Fix it pro car restoration kit

Another simple solution is to utilize a Fix-It pro headlight repair kit. This approach may take some time depending on the depth of the scratch. It is more efficient than the traditional. You can also use a turtle wax headlight lens restoration kit to polish the headlights.

Water stones

Wet the surface with a 1000 or 4000-grit stone before rubbing in a figure-8 motion. As you work, keep adding water to keep your stone lubricated, and remember to wipe away any leftover debris. For best results, use a polishing buffing wheel fine polish after you’ve polished off the whole headlight.

Toothpaste and baking soda

Make a paste with baking soda and a few drops of water, then brush it on the headlight, scratch it, and let it dry for approximately five minutes.

This combination can be used to polish away light scratches with a little elbow grease. Finish by polishing the afflicted area with toothpaste on a towel, then rinsing away any leftovers.

Soda and Vinegar

The vinegar’s acid can assist you to get rid of deep scars that other techniques can’t. Add equal amounts of white vinegar and baking soda and stir until a creamy paste develops, which you should apply to the surface of your headlight lens. Allow it to dry before lightly sanding and buffing it.

How to Remove Scratches from Headlight Cover

The lenses can be easily restored. Because most automobiles have sealed headlight assemblies, replacing the lens is not an option. Some people repair their lenses, but they must also replace the entire set. If you have a high-priced automobile, this might be very pricey. As a result, many people recommend lens repair.

Things that we need:

  • Towels
  • A bucket full of warm water
  • Gloves
  • Masking Tape
  • Polishing Detergent (If Possible)
  • Both wet and dry Sandpaper (600,1200 and 2000 grit)
  • Sanding Block

Steps to Remove Scratches from Headlight Cover

Wash the Headlight Lenses

You must thoroughly clean your headlight lenses. Cleaning your lenses with soapy warm water is the recommended method. Rinse your lenses with a towel until they are clean.

Make sure they’re free of any dirt. Also, keep the area around the lens clean. Allow it to dry completely before wrapping it in masking tape to protect the paint.

Sanding Down the Lenses

Begin by sanding the headlight with wet sandpaper. If there are scratches or the vision is poor, start with 600 grit sandpaper, then move on to 1200, then 2000 grit. Scratches on headlights can be removed using coarse sandpaper.

Finer sandpapers will eliminate scratches caused by the coarse sandpaper on the headlights. The water becomes clearer as you sand more otherwise first time you start sanding milky water may come. After that, sand the lenses until they feel smooth when you touch them.

Give It a Last Polishing Touch

If you want to do it your own, polish the plastic headlight using a 3′′ wool or foam polishing pad. It’s important to keep in mind that the drill they’re using shouldn’t be very fast. When the wools are rotated at a high pace, they become heated.

Start polishing again after adding extra polish as necessary. The headlight will get clearer after some time. Stop polishing the lenses until they are clear. You may finish it off by hand polishing it with polish and a microfiber towel.

How to Remove Scratches from Plastic Headlight Covers?

Plastic headlight lenses yellow and distort the original hue as they age. Another effect is that they pick up scratches, which can cause light output on headlights to be distorted.

Although a headlight restoration kit can handle fading and minor scratches, larger damages are more difficult to remove and can take some time to cure effectively.

These Are Some of the Steps that You Can Follow

1) Feel for scratches by running your palm across the headlight. If you see scratches, soak the sandpaper for 10 minutes in the water bucket.

2) Then, around a sanding block, wrap a piece of 1,000-grit sandpaper.  With the 2,000-grit sandpaper, repeat Step 2, then finish with the 3,000-grit sandpaper.

3) In the drill, insert the polishing wheel from the headlight restoration kit if you bought it earlier.

4) Use the buffing wheel to apply a quarter-size droplet of the polish supplied in the package to the headlight lens.

5) Remove any dried polish with a fresh microfiber cloth and check the lens surface for scratches.

Tips that Will Help

  • When polishing your headlights, use fine-grit sandpaper and water.
  • While using an ice cube to clean scratched headlight lenses, use rubbing alcohol.
  • Purchase a kit for restoring headlights.
  • When polishing headlight lenses, avoid touching them with your bare hands since the oil from your fingertips can produce scratches.
  • Use the plastic cleaner and polisher to remove surface oxidation and cloudy headlight lenses.
  • To remove scratches from headlights that are particularly deep, use water-resistant sandpaper or automotive detailing clay before applying rubbing compound.

Dealing with significant scratches on your headlight lenses may be quite aggravating. They not only obstruct your eyesight, but they also make you an easy target for other drivers, who may not notice you coming due to the distance at which your lights beam.

So, take a look at our suggestions; they will undoubtedly guide you.

Final Note

Headlights are an important feature of the vehicle that must be maintained. Most automobile owners are aware that headlights are one of their vehicle’s most essential protective features. Driving at night without them is highly dangerous.

Scratches can shorten the life of the vehicle and pose problems for the driver when driving. Restoration of the headlights is simple. It can extend the life of the headlights.

So, we hope that these suggestions for removing severe scratches from headlights will save time and money for all of our clients who are looking for a solution!

Leave a Comment